Advice on purchasing a smoker

Cookshack shelves for the SM045are 14 x 18, anything less probably not going to fit a full rack of ribs.   I've had a SM066 for about 8 years and have cooked as low as -20 with no problem holding the temp.  Too cold and the LCD panel gets a little grumpy but can be easily warmed up to respond to set to required settings.

Ditto on dakotasmoke. I have never regretted the cost of my SM066 for one second. It can do 6 racks of ribs without even using the lowest rack, which I think is too close to the heat. I have used it for ribs at an outside temp of 25 degrees with wind - no problem, and I haven't had any display problems on my unit. I bought in 2013, if that has any usefulness. I do try to keep it from getting wet from rain, at least the control unit, but otherwise I am very happy with it. Brisket, pastrami, ribs (pork loin backs and beef short ribs), pork butt, lots and lots of salmon every summer, and chicken wings and turkey thighs. All is good and no worries about the smoker behavior at all. Just solid "set it and forget it." I should say that it lives in a non-heated garage when not in use.

Jdcellar posted:

Hello- I am planning to purchase an electric smoker in the near future.. I have narrowed it down to a Cookshack Elite 45 or a           Smokin It 2D. I want something large enough to smoke 5 to 7 racks of ribs without having to cut them in half. I will also be smoking brisket and pork butts. The Cookshack 025 would probably work for me but I didn’t want to get something to small and regret it later. Temperature where I live usually falls into the 20’s so it will need to be able to hold temperature when it’s cold. Any advice would be appreciated.

I started with the smallest cookshack smoker many years ago (do not remember the year) and  it served me well. I was living in the Chicago area at the time I had no problem smoking meats when the temps dropped below zero. I now use a FEC-100. If you are not competing  I recommend the SM066.

I own a Smokin-It #3. Full racks of ribs fit in it just fine without cutting them.  The #2/2D will require all racks of ribs be cut. The #3 also has a higher wattage element which helps during cold weather.
I have also smoked at 10 deg, just took a longer time to get to temp than it did when it is above freezing.

As far as I know, normal smoker will take about 3-5 minutes to make something hotter. 

hello,

there are some tips on purchasing for a smoker

Affordability. Smokers can range from as little as $50 for a basic unit to $10, 000 or more for an all-in-one combo. Fuel Source. Do you prefer charcoal, wood, pellets, gas, or electricity, Quality. .Size.,Versatility. ...

thanks and regards

Jdcellar posted:

Hello- I am planning to purchase an electric smoker in the near future.. I have narrowed it down to a Cookshack Elite 45 or a           Smokin It 2D. I want something large enough to smoke 5 to 7 racks of ribs without having to cut them in half. I will also be smoking brisket and pork butts. The Cookshack 025 would probably work for me but I didn’t want to get something to small and regret it later. Temperature where I live usually falls into the 20’s so it will need to be able to hold temperature when it’s cold. Any advice would be appreciated.

If you are not sure about getting Cookshack 025, then you probably should have a look at bigger model if you have a budget. I have had the SM025 for several years. I currently really use it almost exclusively for jerky and cold smoking as it is pretty small. So I've kinds outgrown it pretty fast: family gatherings, big parties etc. Though, it's totally OK  for a small dinner party. You won't regret about the quality, and trust me - even in the small 008 smokette models a large brisket can be done.
It just takes some folding.

If you are looking for a quality American built oven you cannot go wrong with a Cookshack Smoker.Almost all the other smoker brands are foreign made. I replaced my Weber Smokey Mountain and bought the Cookshack  Smokette about 20 years ago. I decided I wanted something bigger and replaced it with the Fast Eddie pellet smoker about 5 years ago. I gave the Smokette to my daughter and it is still in service. Her husband is a firefighter and uses it when it is his time to cook for the crew. If you want a quality American built smoker I highly recommend any of the Cookshack smokers.

"Cookshack smokers' even and controllable heat makes a product that is smoky, moist, and tender — just what the judges are looking for — without the hassle and uncertain results obtained by traditional 'stick burner' pits." So that downtown faux-country hipster bar that just added barbecue to its menu? There's a reason it tastes no smokier than your bubbe's brisket.

I live in Idaho where it gets pretty cold.  I started out with an old SMO008, and out grew it fast.  I looked at SMO25, and decided on the SMO45.  I out grew it and got the SMO066.  I have cooked with all of these when they were covered with both snow and ice.  I finally built a cover for them.  The 025, 045, and 066 all use the same sized racks.  The good thing about all of them is they cook moist, and only use 2 to 8 ounces of wood.  I have cooked 3 packer briskets in the 045, and can easily get 5 packers in the 066.  Just a hint;  If you decide on a Cookshack, order it directly from them.  Call them and have them upgrade the racks to stainless steel, and the custom side racks.  The custom side racks will give you more slots to to add more racks.  This will be less expensive in the end. 

Ok, Mike. I'm getting critical on needing new racks for my SM066 to replace the original chrome - they're all getting pitted and nasty and hard to clean. I guess I'm going for stainless, but man, the price is high. Oh well, it is CS. Maybe I'll start with 2 or 3 since that's all I typically use at once.

jay1924 posted:

Ok, Mike. I'm getting critical on needing new racks for my SM066 to replace the original chrome - they're all getting pitted and nasty and hard to clean. I guess I'm going for stainless, but man, the price is high. Oh well, it is CS. Maybe I'll start with 2 or 3 since that's all I typically use at once.

Jay 1924:  This why I tell people that are buying new to ask for the upgrade.  Much less expensive when you start out with the stainless.

I gave the Smokette to my daughter and it is still in service. Her husband is a firefighter and uses it when it is his time to cook for the crew. If you want a quality American built smoker I highly recommend any of the Cookshack smokers.

I just ordered a SM045 so havent received it yet. Are the racks SS or chrome? I was certainly expecting SS for the price. Thx.

Just answered my own question, they are nickel plated, so basically chrome. I suppose I'll swap to SS once these get worn out.

The chrome will last a good long time. The racks I used the most started to get pitted after five years or so of approximately monthly use. Don't know if it makes a difference but I always clean my cooking racks after every smoke.

Jay, for the SM045 I ordered it with the cart and the larger cover, so it should be well kept under my patio. Are there any other areas of concern with these units?  The Masterbuilt had numerous areas of concern, starting with the water pan that corroded out after about 2 years. In the end I could see the entire inside walls were corroding and finally the heat element shorted. Basically I think the Masterbuilt was a minifridge converted to be a smoker.

Flyingman:  I have been running these smokers for over 20 years.  I still have the SMO9 that I started with and it is still running strong.  I also have a SMO45, an SMO66, and a new PG 1000.  I always recommend that people order direct from Cookshack and have them upgrade the grills to Stainless Steel.  They are less expensive this way.  You might call cookshack and tell them that you didn't know this upgrade was available.  There are some differences in the cookshack and Masterbuilt.  First off you will not need to add a water pan.  These smokers cook very moist.  People that do jerky and sausage in them actually have to open the door several times during the cook just to dump moisture.  When you get your smoker look at the inside back wall.  You will see a small tube sticking out.  This is the thermostat for the smoker.  REMEMBER THIS.  you will want to clean it every so often.  You also do not want to load anything that you are smoking so that it is in contact with or close to the tube.  These smokers are very wood stingy.  4 to 6 Oz. of wood will be all you need.  The control unit has a preset start up cycle built in.  There isn't a way to over ride this default.  For the first 30 minutes or so your smoker will run on high.  This is to get the smoke rolling and smoker warmed up.  You may see temperatures above your set temp. during this time.  One other thing for you to do is do a search on this site for "Big Bang" and do some reading.

I almost forgot that I also ordered my smokers with the optional side racks.  These give you 5 slots for the cooking grates instead of the 3 slots that come standard for the SMO45.  I do a lot of cold smoked cheese and with this set up you can shoe horn more product into your smoker